Emergency Response Guidebook (ERG)

This is an online version of the 2008 Emergency Response Guidebook (ERG) which is produced by the USDOT for first responders during the initial phase of a Dangerous goods/Hazardous Materials incident. Have you ever wondered what those four digit numbers on the placards on the side of trucks and rail cars mean? Our online ERG will give you your answer.

GUIDE 132
FLAMMABLE LIQUIDS - CORROSIVE

POTENTIAL HAZARDS

FIRE OR EXPLOSION

  • Flammable/combustible material.
  • May be ignited by heat, sparks or flames.
  • Vapors may form explosive mixtures with air.
  • Vapors may travel to source of ignition and flash back.
  • Most vapors are heavier than air. They will spread along ground and collect in low or confined areas (sewers, basements, tanks).
  • Vapor explosion hazard indoors, outdoors or in sewers.
  • Those substances designated with a P may polymerize explosively when heated or involved in a fire.
  • Runoff to sewer may create fire or explosion hazard.
  • Containers may explode when heated.
  • Many liquids are lighter than water.

HEALTH

  • May cause toxic effects if inhaled or ingested/swallowed.
  • Contact with substance may cause severe burns to skin and eyes.
  • Fire will produce irritating, corrosive and/or toxic gases.
  • Vapors may cause dizziness or suffocation.
  • Runoff from fire control or dilution water may cause pollution.

PUBLIC SAFETY

  • CALL Emergency Response Telephone Number on Shipping Paper first. If Shipping Paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.
  • As an immediate precautionary measure, isolate spill or leak area for at least 50 meters (150 feet) in all directions.
  • Keep unauthorized personnel away.
  • Stay upwind.
  • Keep out of low areas.
  • Ventilate closed spaces before entering.

PROTECTIVE CLOTHING

  • Wear positive pressure self-contained breathing apparatus (SCBA).
  • Wear chemical protective clothing that is specifically recommended by the manufacturer. It may provide little or no thermal protection.
  • Structural firefighters' protective clothing provides limited protection in fire situations ONLY; it is not effective in spill situations where direct contact with the substance is possible.

EVACUATION

Large Spill
  • See Table 1 - Initial Isolation and Protective Action Distances for highlighted materials. For non-highlighted materials, increase, in the downwind direction, as necessary, the isolation distance shown under PUBLIC SAFETY.
Fire
  • If tank, rail car or tank truck is involved in a fire, ISOLATE for 800 meters (1/2 mile) in all directions; also, consider initial evacuation for 800 meters (1/2 mile) in all directions.

EMERGENCY RESPONSE

FIRE

  • Some of these materials may react violently with water.
Small Fire
  • Dry chemical, CO2, water spray or alcohol-resistant foam.
Large Fire
  • Water spray, fog or alcohol-resistant foam.
  • Move containers from fire area if you can do it without risk.
  • Dike fire-control water for later disposal; do not scatter the material.
  • Do not get water inside containers.
Fire involving Tanks or Car/Trailer Loads
  • Fight fire from maximum distance or use unmanned hose holders or monitor nozzles.
  • Cool containers with flooding quantities of water until well after fire is out.
  • Withdraw immediately in case of rising sound from venting safety devices or discoloration of tank.
  • ALWAYS stay away from tanks engulfed in fire.
  • For massive fire, use unmanned hose holders or monitor nozzles; if this is impossible, withdraw from area and let fire burn.

SPILL OR LEAK

  • Fully encapsulating, vapor protective clothing should be worn for spills and leaks with no fire.
  • ELIMINATE all ignition sources (no smoking, flares, sparks or flames in immediate area).
  • All equipment used when handling the product must be grounded.
  • Do not touch or walk through spilled material.
  • Stop leak if you can do it without risk.
  • Prevent entry into waterways, sewers, basements or confined areas.
  • A vapor suppressing foam may be used to reduce vapors.
  • Absorb with earth, sand or other non-combustible material and transfer to containers (except for Hydrazine).
  • Use clean non-sparking tools to collect absorbed material.
Large Spill
  • Dike far ahead of liquid spill for later disposal.
  • Water spray may reduce vapor; but may not prevent ignition in closed spaces.

FIRST AID

  • Move victim to fresh air.
  • Call 911 or emergency medical service.
  • Give artificial respiration if victim is not breathing.
  • Do not use mouth-to-mouth method if victim ingested or inhaled the substance; give artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device.
  • Administer oxygen if breathing is difficult.
  • Remove and isolate contaminated clothing and shoes.
  • In case of contact with substance, immediately flush skin or eyes with running water for at least 20 minutes.
  • In case of burns, immediately cool affected skin for as long as possible with cold water. Do not remove clothing if adhering to skin.
  • Keep victim warm and quiet.
  • Effects of exposure (inhalation, ingestion or skin contact) to substance may be delayed.
  • Ensure that medical personnel are aware of the material(s) involved and take precautions to protect themselves.

Data Source for our online 2008 ERG

This information was compiled from the 2008 Emergency Response Guidebook (2008 ERG) which is produced by the U.S. Department of Transportation.

(Data last updated/verified: Oct. 2, 2011)

Related Resources

Disclaimer

WARNING: These pages are for general reference and educational purposes only and MUST NOT be relied upon as a sole source to determine regulatory compliance or where matters of life and health are concerned. This site and the author do not warrant or guarantee the accuracy or the sufficiency of the information provided and do not assume any responsibility for its use.

To ensure regulatory compliance when transporting hazardous materials or dangerous goods, one must receive proper training and certification from a qualified instructor and refer to the current year's Code of Federal Regulations Title 49 (49CFR) or your country's shipping regulations. In matters regarding workplace safety, refer to current OSHA regulations (29CFR) and NIOSH guidelines or your own country's health and safety regulations. No one should ever enter into a hazardous environment without proper training from qualified instructors.

Citing this page

If you need to cite this page, you can copy this text: